1959-1969 Volvo 122S labor times
1.6L B16B I4 (dual SU carburetors, ~85 hp)
These times cover the Volvo 122S 1.6L B16B I4 (dual SU carburetors, ~85 hp) for model years 1959, 1960, 1961, 1962, 1963, 1964, 1965, 1966, 1967, 1968, 1969.
Change vehicle
per hour
Enter a rate to see the labor cost of each job. Many US shops charge somewhere between $100 and $200 an hour.
Most looked up
- Brake Pads - Front1.2 hr1.0 to 1.5
- Brake Rotors - Front Pair1.5 hr1.2 to 2.0
- Oil Change0.5 hr0.4 to 0.6
- Alternator1.5 hr1.2 to 2.0
- Starter2.0 hr1.5 to 2.8
- Water Pump2.5 hr2.0 to 3.0
- Thermostat1.2 hr0.8 to 1.8
- Tire Rotation0.5 hr0.4 to 0.6
Maintenance
- 100K Service6.5 hr5.5 to 8.0
- 30K Service2.5 hr2.0 to 3.5
- 60K Service4.5 hr3.5 to 5.5
- 90K Service4.5 hr3.5 to 5.5
- AC System Diagnosis1.5 hr1.0 to 2.0
- Air Filter0.2 hr0.1 to 0.3
- Battery Test0.4 hr0.3 to 0.5
- Charging System Test0.5 hr0.4 to 0.7
- Compression Test0.7 hr0.6 to 0.8
- Cooling System Pressure Test0.5 hr0.3 to 0.7
- Diagnostic Scan1.3 hr1.0 to 1.6
- Differential Service1.3 hr1.0 to 1.6
- Drivability Diagnosis1.3 hr1.0 to 1.6
- Electrical Diagnosis1.5 hr1.0 to 3.0
- Emissions Inspection0.7 hr0.6 to 0.8
- Fluid Leak Diagnosis1.3 hr1.0 to 1.6
- Leak-Down Test2.0 hr1.6 to 2.4
- Noise Diagnosis1.5 hr1.0 to 3.0
- Pre-Purchase Inspection2.0 hr1.6 to 2.4
- State Inspection0.5 hr0.3 to 0.8
- Tire Balance0.7 hr0.6 to 0.8
- Tire Mount and Balance1.0 hr0.8 to 1.2
- Tire Rotation0.5 hr0.4 to 0.6
- Transmission Service2.0 hr1.6 to 2.4
- Tune-Up - Major3.3 hr2.6 to 4.0
- Tune-Up - Minor2.0 hr1.6 to 2.4
- Wheel Alignment1.0 hr0.8 to 1.5
- Wiper Blade Replacement0.2 hr0.1 to 0.3
Brakes
- Brake Bleed - All Four1.0 hr0.8 to 1.3
- Brake Booster2.5 hr2.0 to 3.5
- Brake Booster Check Valve0.5 hr0.3 to 0.8
- Brake Caliper - Front1.5 hr1.2 to 2.0
- Brake Caliper - Rear2.0 hr1.6 to 2.4
- Brake Caliper Bracket1.5 hr1.2 to 2.0
- Brake Caliper Rebuild - Front8.1 hr6.5 to 9.7
- Brake Caliper Rebuild - Rear8.1 hr6.5 to 9.7
- Brake Caliper Slide Pins1.0 hr0.8 to 1.2
- Brake Drum - Rear2.0 hr1.6 to 2.4
- Brake Fluid Flush0.8 hr0.6 to 1.0
- Brake Hose - Front1.0 hr0.8 to 1.3
- Brake Hose - Rear1.2 hr0.9 to 1.5
- Brake Light Switch0.5 hr0.3 to 0.8
- Brake Line - Single1.5 hr1.0 to 2.5
- Brake Lines - Complete Set7.2 hr5.8 to 8.6
- Brake Master Cylinder2.0 hr1.5 to 2.5
- Brake Master Cylinder Rebuild2.5 hr2.0 to 3.5
- Brake Pads - Front1.2 hr1.0 to 1.5
- Brake Pads - Rear1.6 hr1.3 to 1.9
- Brake Pads and Rotors - Front2.5 hr2.0 to 3.0
- Brake Pads and Rotors - Rear2.5 hr2.0 to 3.0
- Brake Proportioning Valve1.5 hr1.0 to 2.0
- Brake Rotor - Front Single1.2 hr0.9 to 1.5
- Brake Rotor - Rear Single0.6 hr0.5 to 0.7
- Brake Rotors - Front Pair1.5 hr1.2 to 2.0
- Brake Rotors - Rear Pair2.5 hr2.0 to 3.0
- Drum Brake Hardware Kit2.6 hr2.1 to 3.1
- Drum Brake Shoes - Rear2.0 hr1.6 to 2.4
- Electronic Parking Brake Motor2.0 hr1.6 to 2.4
- Front Brake Pad Replacement2.0 hr1.6 to 2.4
- Parking Brake Actuator2.0 hr1.6 to 2.4
- Parking Brake Cable2.0 hr1.6 to 2.4
- Parking Brake Shoes2.0 hr1.6 to 2.4
- Rear Brake Shoe Replacement2.9 hr2.3 to 3.5
- Wheel Cylinder2.0 hr1.6 to 2.4
Engine
- Camshaft R&R12.7 hr10.2 to 15.2
- Connecting Rod Bearings18.2 hr14.6 to 21.8
- Crankshaft R&R35.1 hr28.1 to 42.1
- Cylinder Head R&R16.6 hr13.3 to 19.9
- Cylinder Head Resurface11.1 hr8.9 to 13.3
- Engine Mount - Front2.0 hr1.6 to 2.4
- Engine Mount - Rear2.0 hr1.6 to 2.4
- Engine Mounts - All5.9 hr4.7 to 7.1
- Engine R&R23.4 hr18.7 to 28.1
- Engine Rebuild81.3 hr65.0 to 97.6
- Exhaust Manifold4.6 hr3.7 to 5.5
- Exhaust Manifold Gasket3.9 hr3.1 to 4.7
- Fan Belt Replacement1.2 hr1.0 to 1.4
- Flexplate11.1 hr8.9 to 13.3
- Flywheel9.8 hr7.8 to 11.8
- Freeze Plug - Single4.6 hr3.7 to 5.5
- Freeze Plugs - All20.3 hr16.2 to 24.4
- Front Main Seal7.2 hr5.8 to 8.6
- Full Engine Tune-Up3.3 hr2.6 to 4.0
- Harmonic Balancer2.6 hr2.1 to 3.1
- Head Gasket - Single8.5 hr7.0 to 10.0
- Head Gaskets - Both14.5 hr12.3 to 18.1
- Idle Air Control Valve1.0 hr0.8 to 1.2
- Idler Pulley1.0 hr0.8 to 1.2
- Intake Manifold4.6 hr3.7 to 5.5
- Intake Manifold Gasket3.5 hr2.8 to 4.2
- Lifter - Single6.6 hr5.3 to 7.9
- Lifters/Tappets - All14.4 hr11.5 to 17.3
- Long Block Replacement18.2 hr14.6 to 21.8
- Main Bearings20.8 hr16.6 to 25.0
- Oil Change0.5 hr0.4 to 0.6
- Oil Level Sensor1.6 hr1.3 to 1.9
- Oil Pan Gasket4.6 hr3.7 to 5.5
- Oil Pan Replacement4.6 hr3.7 to 5.5
- Oil Pressure Sensor1.0 hr0.8 to 1.2
- Oil Pump8.5 hr6.8 to 10.2
- Oil Separator/PCV2.0 hr1.6 to 2.4
- PCV Valve0.3 hr0.2 to 0.5
- Piston - Single9.4 hr7.5 to 11.3
- Piston Rings - All23.4 hr18.7 to 28.1
- Pistons - All30.4 hr24.3 to 36.5
- Rear Main Seal9.8 hr7.8 to 11.8
- Rocker Arms - All5.9 hr4.7 to 7.1
- Short Block Replacement23.4 hr18.7 to 28.1
- Throttle Position Sensor1.0 hr0.8 to 1.2
- Transmission Mount2.0 hr1.6 to 2.4
- Valve Adjustment3.3 hr2.6 to 4.0
- Valve Cover Gasket - Single1.5 hr1.2 to 2.0
- Valve Cover Gaskets - Both2.6 hr2.2 to 3.2
- Valve Job - Complete20.8 hr16.6 to 25.0
- Valve Seals11.1 hr8.9 to 13.3
- Valve Spring - Single3.5 hr2.8 to 4.2
- Valve Springs - All11.1 hr8.9 to 13.3
Cooling
- Coolant Bypass Pipe2.5 hr2.0 to 3.5
- Coolant Flush1.0 hr0.8 to 1.3
- Coolant Reservoir0.7 hr0.6 to 0.8
- Coolant Temperature Sensor0.5 hr0.3 to 0.8
- Cooling Fan Assembly1.6 hr1.3 to 1.9
- Cooling Fan Clutch1.0 hr0.8 to 1.2
- Cooling Fan Motor1.2 hr0.8 to 1.5
- Cooling Fan Relay0.7 hr0.6 to 0.8
- Heater Control Valve1.2 hr0.8 to 1.8
- Heater Core6.5 hr5.5 to 8.0
- Heater Hoses1.2 hr0.8 to 1.8
- Radiator2.5 hr2.0 to 3.5
- Radiator Cap0.2 hr0.1 to 0.3
- Radiator Hose - Lower0.6 hr0.4 to 0.9
- Radiator Hose - Upper0.5 hr0.4 to 0.7
- Radiator Hoses - Both2.0 hr1.6 to 2.4
- Radiator Removal and Service2.5 hr2.0 to 3.5
- Thermostat1.2 hr0.8 to 1.8
- Thermostat Housing1.2 hr0.8 to 1.8
- Water Pump2.5 hr2.0 to 3.0
Ignition
- Distributor2.0 hr1.6 to 2.4
- Distributor Cap and Rotor1.3 hr1.0 to 1.6
- Distributor Rebuild3.3 hr2.6 to 4.0
- Ignition Coil - Single0.4 hr0.3 to 0.5
- Ignition Coils - All2.5 hr2.0 to 3.0
- Ignition Control Module1.6 hr1.3 to 1.9
- Ignition Lock Cylinder1.6 hr1.3 to 1.9
- Ignition Points and Condenser Replacement2.0 hr1.6 to 2.4
- Ignition Switch1.6 hr1.3 to 1.9
- Ignition Timing Adjustment0.7 hr0.6 to 0.8
- Spark Plug Wires0.7 hr0.6 to 0.8
- Spark Plugs0.8 hr0.6 to 1.2
Fuel system
- Fuel Cap0.3 hr0.3 to 0.4
- Fuel Filler Neck1.6 hr1.3 to 1.9
- Fuel Filter0.5 hr0.3 to 0.8
- Fuel Injection Pump Timing Adjustment2.0 hr1.6 to 2.4
- Fuel Injection System Diagnostics and Troubleshooting2.0 hr1.6 to 2.4
- Fuel Injector - Single0.9 hr0.7 to 1.1
- Fuel Injector Cleaning1.3 hr1.0 to 1.6
- Fuel Injectors - All5.9 hr4.7 to 7.1
- Fuel Level Sensor2.0 hr1.6 to 2.4
- Fuel Line - High Pressure2.0 hr1.6 to 2.4
- Fuel Line - Return2.0 hr1.6 to 2.4
- Fuel Line and Filter Service0.7 hr0.6 to 0.8
- Fuel Pressure Regulator1.6 hr1.3 to 1.9
- Fuel Pump2.6 hr2.1 to 3.1
- Fuel Tank3.3 hr2.6 to 4.0
- Fuel Tank Strap2.0 hr1.6 to 2.4
- High Pressure Fuel Pump3.3 hr2.6 to 4.0
- Mechanical Fuel Injection Pump Rebuild4.9 hr3.9 to 5.9
- Mechanical Fuel Injection Pump Removal and Installation7.6 hr6.1 to 9.1
- Mechanical Fuel Injector Service3.3 hr2.6 to 4.0
- Mechanical Fuel Pump Service2.0 hr1.6 to 2.4
- Warm-Up Regulator Service2.0 hr1.6 to 2.4
Electrical
- Alternator1.5 hr1.2 to 2.0
- Alternator Belt0.7 hr0.6 to 0.8
- Amplifier2.0 hr1.6 to 2.4
- Antenna0.7 hr0.6 to 0.8
- Battery0.3 hr0.2 to 0.5
- Battery Cable - Negative0.5 hr0.3 to 0.8
- Battery Cable - Positive1.0 hr0.8 to 1.2
- Battery Cables - Both0.8 hr0.6 to 1.2
- Battery Terminal0.4 hr0.3 to 0.5
- Blower Motor1.2 hr0.8 to 1.8
- Blower Motor Control Module1.6 hr1.3 to 1.9
- Blower Motor Resistor0.8 hr0.5 to 1.2
- Combination Switch1.2 hr0.8 to 1.8
- Dimmer Switch1.0 hr0.8 to 1.2
- Door Lock Actuator - Front2.0 hr1.6 to 2.4
- Door Lock Actuator - Rear2.0 hr1.6 to 2.4
- Fog Light Assembly1.0 hr0.8 to 1.2
- Fog Light Bulb0.3 hr0.2 to 0.5
- Fuel Pump Relay0.7 hr0.6 to 0.8
- Fuse Box - Engine Bay1.5 hr1.0 to 2.5
- Fuse Box - Interior2.0 hr1.6 to 2.4
- Generator Service and Rebuild11.4 hr9.1 to 13.7
- Headlight Assembly0.8 hr0.5 to 1.2
- Headlight Bulb - Single0.3 hr0.2 to 0.5
- Headlight Bulbs - Pair0.4 hr0.3 to 0.6
- Headlight Switch1.0 hr0.8 to 1.2
- Heated Seat Module2.0 hr1.6 to 2.4
- Horn0.8 hr0.5 to 1.2
- Horn Relay0.7 hr0.6 to 0.8
- Instrument Cluster2.0 hr1.6 to 2.4
- Instrument Cluster Service2.6 hr2.1 to 3.1
- LED Headlight Module2.0 hr1.6 to 2.4
- Main Relay1.2 hr0.8 to 1.8
- Power Antenna Motor1.0 hr0.8 to 1.2
- Power Mirror Motor1.3 hr1.0 to 1.6
- Power Seat Motor2.0 hr1.6 to 2.4
- Power Window Motor - Front2.0 hr1.6 to 2.4
- Power Window Motor - Rear2.0 hr1.6 to 2.4
- Power Window Regulator - Front2.5 hr2.0 to 3.5
- Power Window Regulator - Rear2.3 hr1.8 to 2.8
- Radio/Head Unit1.2 hr0.8 to 1.8
- Relay - Generic0.5 hr0.3 to 1.2
- Seat Heater Element3.3 hr2.6 to 4.0
- Side Mirror Assembly0.8 hr0.5 to 1.2
- Speaker - Dash1.2 hr0.8 to 1.8
- Speaker - Door1.0 hr0.8 to 1.2
- Speedometer2.0 hr1.6 to 2.4
- Speedometer Cable2.0 hr1.6 to 2.4
- Starter2.0 hr1.5 to 2.8
- Starter Solenoid2.0 hr1.6 to 2.4
- Subwoofer1.5 hr1.0 to 2.5
- Tail Light Assembly1.0 hr0.8 to 1.2
- Tail Light Bulb0.3 hr0.2 to 0.5
- Trunk/Liftgate Actuator1.6 hr1.3 to 1.9
- Turn Signal Bulb - Front0.4 hr0.3 to 0.5
- Turn Signal Bulb - Rear0.4 hr0.3 to 0.5
- Turn Signal Switch2.0 hr1.6 to 2.4
- Voltage Regulator2.0 hr1.6 to 2.4
- Washer Pump0.7 hr0.6 to 0.8
- Washer Reservoir1.2 hr0.8 to 1.8
- Window Motor and Regulator - Front2.5 hr2.0 to 3.5
- Window Motor and Regulator - Rear2.0 hr1.6 to 2.4
- Wiper Linkage1.5 hr1.2 to 2.0
- Wiper Motor - Front1.2 hr0.9 to 1.5
- Wiper Motor - Rear1.6 hr1.3 to 1.9
- Wiper Switch1.2 hr0.8 to 1.8
Suspension
- Ball Joint - Lower3.4 hr2.7 to 4.1
- Ball Joint - Upper2.5 hr2.0 to 3.0
- Ball Joints - Upper and Lower5.8 hr4.9 to 7.2
- Coil Spring - Front2.6 hr2.1 to 3.1
- Coil Spring - Rear2.0 hr1.6 to 2.4
- Coil Springs - Front Pair4.4 hr3.8 to 5.5
- Coil Springs - Rear Pair2.5 hr2.0 to 3.0
- Control Arm Bushing - Front Lower2.5 hr2.0 to 3.5
- Control Arm Bushing - Front Upper2.5 hr2.0 to 3.5
- Control Arm Bushing - Rear2.6 hr2.1 to 3.1
- Front Struts - Pair4.2 hr3.4 to 5.0
- Front Suspension Rebuild8.5 hr7.0 to 10.5
- Knuckle/Spindle - Front3.5 hr2.8 to 4.5
- Lateral Arm2.0 hr1.6 to 2.4
- Lower Control Arm - Front2.0 hr1.6 to 2.4
- Lower Control Arm - Rear2.0 hr1.6 to 2.4
- Radius Arm3.3 hr2.6 to 4.0
- Radius Arm Bushing2.6 hr2.1 to 3.1
- Rear Shocks - Pair2.5 hr2.0 to 3.0
- Rear Suspension Service3.5 hr2.8 to 4.5
- Shock Absorber - Front (one side)0.6 hr0.5 to 0.8
- Shock Absorber - Rear (one side)0.5 hr0.4 to 0.6
- Strut Assembly - Front2.0 hr1.6 to 2.4
- Strut Bearing2.6 hr2.1 to 3.1
- Strut Mount - Front2.6 hr2.1 to 3.1
- Subframe8.5 hr6.8 to 10.2
- Subframe Bushing4.6 hr3.7 to 5.5
- Sway Bar - Front1.5 hr1.2 to 2.0
- Sway Bar - Rear1.6 hr1.3 to 1.9
- Sway Bar Bushing - Front1.3 hr1.0 to 1.6
- Sway Bar Bushing - Rear1.0 hr0.8 to 1.2
- Sway Bar Link - Front1.0 hr0.8 to 1.2
- Sway Bar Link - Rear1.0 hr0.8 to 1.2
- Sway Bar Links - Front Pair1.7 hr1.4 to 2.0
- Torsion Bar2.6 hr2.1 to 3.1
- Torsion Bar Adjustment0.7 hr0.6 to 0.8
- Trailing Arm3.3 hr2.6 to 4.0
- Trailing Arm Bushing2.5 hr2.0 to 3.5
- Upper Control Arm - Front2.0 hr1.5 to 2.5
- Upper Control Arm - Rear2.0 hr1.6 to 2.4
Steering
- Center Link/Drag Link2.0 hr1.6 to 2.4
- Idler Arm1.6 hr1.3 to 1.9
- Pitman Arm2.0 hr1.6 to 2.4
- Power Steering Hose - High Pressure1.6 hr1.3 to 1.9
- Power Steering Hose - Return1.6 hr1.3 to 1.9
- Power Steering Reservoir1.0 hr0.8 to 1.2
- Rack and Pinion Boots2.6 hr2.1 to 3.1
- Steering Angle Sensor1.3 hr1.0 to 1.6
- Steering Box Adjustment1.0 hr0.8 to 1.2
- Steering Column3.5 hr2.8 to 4.5
- Steering Coupler2.0 hr1.6 to 2.4
- Steering Damper1.0 hr0.8 to 1.2
- Steering Shaft - Intermediate2.5 hr2.0 to 3.5
- Steering Shaft - Upper2.0 hr1.6 to 2.4
- Steering Wheel1.5 hr1.0 to 2.0
- Tie Rod Assembly1.5 hr1.2 to 2.0
- Tie Rod End - Inner1.5 hr1.2 to 2.0
- Tie Rod End - Outer1.2 hr0.8 to 1.5
- Tie Rods - Both Sides2.0 hr1.7 to 2.6
Drivetrain
- Axle Seal - Rear2.0 hr1.6 to 2.4
- Axle Shaft - Rear2.5 hr2.0 to 3.5
- CV Axle - Rear2.6 hr2.1 to 3.1
- CV Boot - Inner3.3 hr2.6 to 4.0
- CV Boot - Outer2.0 hr1.6 to 2.4
- Differential Cover Gasket2.0 hr1.6 to 2.4
- Differential Fluid Change - Rear0.8 hr0.6 to 1.2
- Differential Pinion Seal2.5 hr2.0 to 3.5
- Differential Rebuild - Rear17.9 hr14.3 to 21.5
- Driveshaft - Rear2.6 hr2.1 to 3.1
- Driveshaft Center Support Bearing2.0 hr1.6 to 2.4
- Limited Slip Clutch Pack5.9 hr4.7 to 7.1
- Ring and Pinion7.2 hr5.8 to 8.6
- U-Joint2.0 hr1.6 to 2.4
- Wheel Bearing - Press-In Front2.5 hr2.0 to 3.5
- Wheel Bearing - Press-In Rear2.5 hr2.0 to 3.5
- Wheel Bearing Hub - Front2.0 hr1.5 to 2.5
- Wheel Bearing Hub - Rear2.0 hr1.5 to 2.5
- Wheel Stud - Front0.5 hr0.4 to 0.6
- Wheel Stud - Rear0.6 hr0.5 to 0.8
Transmission
- Automatic Transmission Fluid and Filter Change2.0 hr1.6 to 2.4
- Clutch Cable2.0 hr1.6 to 2.4
- Clutch Disc7.2 hr5.8 to 8.6
- Clutch Hydraulic Line2.0 hr1.6 to 2.4
- Clutch Kit8.5 hr6.8 to 10.2
- Clutch Master Cylinder3.3 hr2.6 to 4.0
- Clutch Slave Cylinder3.3 hr2.6 to 4.0
- Flywheel Resurface7.2 hr5.8 to 8.6
- Manual Trans Fluid Change0.7 hr0.6 to 0.8
- Neutral Safety Switch1.6 hr1.3 to 1.9
- Overdrive Solenoid3.3 hr2.6 to 4.0
- Pilot Bearing8.5 hr6.8 to 10.2
- Pressure Plate7.2 hr5.8 to 8.6
- Shift Cable2.0 hr1.6 to 2.4
- Shift Fork11.1 hr8.9 to 13.3
- Shift Linkage2.0 hr1.6 to 2.4
- Synchros - All20.3 hr16.2 to 24.4
- Synchros - Single Gear6.6 hr5.3 to 7.9
- Throw-Out Bearing8.5 hr6.8 to 10.2
- Torque Converter11.1 hr8.9 to 13.3
- Transmission Control Module2.0 hr1.6 to 2.4
- Transmission Filter2.0 hr1.6 to 2.4
- Transmission Filter and Fluid2.0 hr1.6 to 2.4
- Transmission Fluid Change0.9 hr0.7 to 1.1
- Transmission Flush1.2 hr1.0 to 1.5
- Transmission Input Shaft Bearing11.1 hr8.9 to 13.3
- Transmission Output Shaft Bearing8.5 hr6.8 to 10.2
- Transmission Pan Gasket2.0 hr1.6 to 2.4
- Transmission R&R - Automatic16.6 hr13.3 to 19.9
- Transmission R&R - Manual12.7 hr10.2 to 15.2
- Transmission Rebuild - Automatic39.0 hr31.2 to 46.8
- Transmission Rebuild - Manual8.1 hr6.9 to 9.3
- Valve Body8.5 hr6.8 to 10.2
Exhaust
- Downpipe3.3 hr2.6 to 4.0
- Exhaust Clamp0.4 hr0.3 to 0.5
- Exhaust Gasket - Front2.0 hr1.6 to 2.4
- Exhaust Gasket - Rear3.3 hr2.6 to 4.0
- Exhaust Hangers0.7 hr0.6 to 0.8
- Exhaust Manifold Studs4.6 hr3.7 to 5.5
- Exhaust Pipe - Rear Section1.6 hr1.3 to 1.9
- Exhaust Tip0.4 hr0.3 to 0.5
- Flex Pipe2.0 hr1.6 to 2.4
- Front Pipe2.0 hr1.6 to 2.4
- Intermediate Pipe1.6 hr1.3 to 1.9
- Muffler1.0 hr0.8 to 1.2
- Resonator1.0 hr0.8 to 1.2
- Tail Pipe1.0 hr0.8 to 1.2
Heating and A/C
- AC Accumulator2.0 hr1.6 to 2.4
- AC Clutch Coil2.0 hr1.6 to 2.4
- AC Compressor3.5 hr3.0 to 4.5
- AC Compressor Clutch2.0 hr1.7 to 2.5
- AC Compressor Oil Add1.2 hr0.8 to 1.5
- AC Condenser2.0 hr1.6 to 2.4
- AC Evaporator8.5 hr7.2 to 10.6
- AC Expansion Valve (TXV)3.5 hr2.8 to 4.5
- AC High Pressure Switch0.7 hr0.6 to 0.8
- AC Hose - High Side2.0 hr1.6 to 2.4
- AC Hose - Low Side2.0 hr1.6 to 2.4
- AC Hose Assembly2.5 hr1.8 to 3.5
- AC Low Pressure Switch0.7 hr0.6 to 0.8
- AC Orifice Tube2.0 hr1.6 to 2.4
- AC Pressure Sensor0.7 hr0.6 to 0.8
- AC Receiver/Drier2.0 hr1.6 to 2.4
- AC Recharge0.7 hr0.6 to 0.8
- Blend Door Actuator2.0 hr1.6 to 2.4
- Climate Control Module2.0 hr1.6 to 2.4
- HVAC Control Panel1.5 hr1.0 to 2.5
- Mode Door Actuator2.6 hr2.1 to 3.1
- Recirculation Door Actuator2.0 hr1.6 to 2.4
Body
- Bumper Cover - Front0.5 hr0.4 to 0.6
- Bumper Cover - Rear0.5 hr0.4 to 0.6
- Bumper Reinforcement - Front2.5 hr2.0 to 3.5
- Bumper Reinforcement - Rear1.5 hr1.3 to 1.9
- Door Check/Stop0.5 hr0.3 to 0.8
- Door Glass2.0 hr1.5 to 2.5
- Door Handle - Exterior1.0 hr0.8 to 1.2
- Door Handle - Interior1.0 hr0.8 to 1.2
- Door Hinge2.0 hr1.6 to 2.4
- Door Shell4.5 hr3.5 to 6.0
- Door Skin4.6 hr3.7 to 5.5
- Door Weatherstrip1.3 hr1.0 to 1.6
- Fender3.3 hr2.6 to 4.0
- Fender Liner0.7 hr0.6 to 0.8
- Grille1.0 hr0.8 to 1.2
- Hood0.8 hr0.6 to 1.2
- Hood Hinge1.2 hr0.8 to 1.8
- Hood Latch1.0 hr0.8 to 1.2
- Hood Release Cable1.6 hr1.3 to 1.9
- Hood Strut0.4 hr0.3 to 0.5
- Liftgate4.6 hr3.7 to 5.5
- Liftgate Motor2.0 hr1.6 to 2.4
- Liftgate Strut0.7 hr0.6 to 0.8
- Quarter Glass2.0 hr1.6 to 2.4
- Quarter Panel20.8 hr16.6 to 25.0
- Rear Window2.5 hr2.0 to 3.5
- Rocker Panel10.4 hr8.3 to 12.5
- Side Mirror Glass0.5 hr0.3 to 0.8
- Trunk Hinge1.5 hr1.0 to 2.2
- Trunk Latch0.8 hr0.5 to 1.2
- Trunk Lid1.5 hr1.2 to 2.0
- Trunk Strut0.5 hr0.3 to 0.7
- Vent Glass1.5 hr1.0 to 2.5
- Windshield2.0 hr1.6 to 2.4
- Windshield Molding1.5 hr1.0 to 2.5
Interior
- Armrest0.5 hr0.3 to 0.8
- Carpet5.9 hr4.7 to 7.1
- Center Console0.5 hr0.4 to 0.6
- Dash Pad3.5 hr3.0 to 4.4
- Dashboard8.5 hr7.0 to 10.5
- Door Panel1.3 hr1.0 to 1.6
- Floor Mat Hooks0.3 hr0.2 to 0.5
- Glove Box0.7 hr0.6 to 0.8
- Glove Box Latch0.3 hr0.2 to 0.5
- Headliner5.9 hr4.7 to 7.1
- Pedal Pads0.3 hr0.2 to 0.5
- Rearview Mirror0.4 hr0.3 to 0.5
- Seat - Front1.2 hr0.8 to 1.8
- Seat - Rear1.2 hr0.8 to 1.8
- Seat Belt1.2 hr0.8 to 1.8
- Seat Belt Buckle1.0 hr0.8 to 1.2
- Seat Cover2.5 hr1.8 to 3.5
- Seat Foam2.5 hr1.8 to 3.5
- Seat Track1.5 hr1.0 to 2.5
- Shifter Boot0.7 hr0.6 to 0.8
- Shifter Knob0.3 hr0.2 to 0.5
- Steering Wheel Cover0.3 hr0.2 to 0.5
- Sun Visor0.5 hr0.3 to 0.7
Other
- Engine Mount - Strut2.0 hr1.6 to 2.4
- Engine Mount - Torque Axis2.0 hr1.6 to 2.4
Hours are what a professional technician takes with the right tools. When a range is shown, it is the spread a job can take depending on condition. Parts are extra.
Need torque specs, fluids or repair steps for this car? See it on the Open Labor Project